Wheels 2021 Category Banner

Shop For Your Vehicle

Fuel Regulators



Replacement Fuel Pressure Regulator

The fuel injectors are electromechanical systems powered by the PCM (Powertrain Control Module). One terminal is attached to the 12V on the injector. When the PCM sits on the other terminal, the coil in the injector lifts the plunger, causing the fuel to be sprayed. The fuel pressure in an electronically powered fuel-injected engine that has to be in a specific location to help ensure that there is enough demand of available fuel to the fuel injectors under all system parameters of the engine.

The fuel pump supplies fuel to the fuel rail at a steady speed, and the fuel rail installed by the injectors sprays fuel into the intake ports. The PCM differs the length of the pulse, the period the injectors are ground to accommodate the engine's pressure. The pulse width is reduced at rest and longer when the engine is under pressure, and more fuel is required. But without a means of managing the pressure, there might be quite enough pressure at the idle or not enough at the wide-open throttle.

The fuel pressure regulator keeps the fuel pressure inside the particular range. It is positioned on the fuel rail and includes a diaphragm and a spring. The port joins the regulator to the engine vacuum and is also linked to the fuel return line, helping the fuel flow back to the reservoir or the tank. When less fuel is needed in standby, the engine vacuum works against both the diaphragm and spring to enable excess fuel to flow back to the tank. When the throttle is activated and more fuel is required, the decreased vacuum encourages the diaphragm and spring to minimize the return flow rate, guaranteeing enough energy to maximize the pulse width.

Usually, the fuel pressure regulator would struggle to shut, leading to too much fuel pressure, a great mixture, low fuel economy, and unnecessary emissions. If you detach the vacuum hose from the regulator and the fuel pressure does not increase, the regulator will probably be defective. However, there may be a vacuum pulse issue created by a short or broken vacuum line, so be sure to consider a vacuum with a hand-held vacuum pump. Fuel pressure must be reduced as the vacuum rises. If not, confirm that the return line is not interrupted and uninstall and install a new regulator.

That being said, if the spring fails in the regulator or the regulator spills, this will lead to low fuel pressure and a poor state. If the fuel pressure is low and does not increase when the fuel return line is turned off, the fuel pump is quite likely to be at fault. However, the regulator should be removed and replaced by a new one if the pressure does increase.

Symptoms of a Bad Fuel Pressure Regulator

Bad Fuel Economy

The fuel pressure regulator's primary purpose is to regulate the pressure of the fuel supplied to the motor. If the pressure is relatively small, the fuel can travel in a prolonged manner. It is also common to have the same disadvantage of getting too much fuel pressure. This could contribute to the 'flooding' of the combustion chamber. The engine has more fuel in the mixture than the air. This could also contribute to a decrease in fuel economy. It would be good to get a mechanic to assess the issue and identify the source of the issue for you.

Bad Acceleration

It is one of the signs that many car owners will first experience from their auto when they have a low fuel pressure regulator. When they step onto the gas pedal, the vehicle does not accelerate more naturally. It's slow. No matter how many times you press on the pedal, the car isn't moving fast enough.

Fuel Leaks

Another indication of the problem with the vehicle's fuel pressure regulator is fuel leakage. If the diaphragm of the fuel pressure regulator or any of the seals fails, fuel leakage can happen. A defective regulator may not only leak fuel, which is a possible safety hazard but may also cause performance problems. A fuel leak typically causes a conspicuous scent of fuel and can also cause problems with engine efficiency.

Misfires

One of the first signs of a potential problem with the fuel pressure regulator is the engine's efficiency. If the vehicle's fuel pressure regulator breaks or has some issues, its fuel pressure would be disrupted. This will switch off the engine's air-fuel ratio and the tune that could have a drastic impact on the vehicle's output.

Exhaust Emitting Black Smoke

There might be a lot of explanations why you have black smoke emitting from the exhaust. It may be because of an issue with the system of how the carburetor was installed. Black smoke can also be a symptom of a blocked air filter. Black smoke may also be generated in the worst possible case.

Irrespective of the component failure, we have a replacement fuel pressure regulator to preserve average engine performance. All of the regulators we sell are produced to OE specifications to address each vehicle’s unique fuel pressure specifications and ensure ease of fitting and excellent engine efficiency. We have Fuel Pressure Regulator from AEM Electronics, Aeromotive, Holley, NRG, Turbosmart, and much more!

Why Switch to Vivid Racing?

From fitment help from our in-house experts to shipping packages, we'll take care of you and your order every step of the way. We know how much of a financial investment you're making in a set of wheels or accessories and upgrades, and in return, we'll deliver service and product that is second to none.

At Vivid Racing, we love cars. Cars are our vice in life. We love the automotive community and love our customers who think like us.

Finding a perfect aftermarket product is not an easy job. We fully understand it, and we are here to help you find the best modifications for your car.

We specialize in double takes! Our passion, simply, is helping you to build the car you always dreamed of. Everyone has their favorite look, color, effect, and desires, and we are here to help you achieve your goal.

Vivid Racing ensures that they meet the customer's expectations regarding quality, size, and strength.

The company always provides quality aftermarket products for applications where you need speed and good looks, such as racing vehicles.

Vivid Racing carries high-performance parts for almost any need. Click these links to choose from our selection of Body Kits, Big Brake Kits, Seats, Custom Wheels and Tires, Engine Parts, Exhaust Parts, Intakes, Suspension, and Transmission Parts.

Buying from Vivid Racing is the best choice you can make. We back every part we sell with our guarantee of satisfaction.

Buy online or give one of our world-class sales professionals a call at 1-480-966-3040. If you don't see what you are looking for, Call Us.

We can help. Vivid Racing was voted #1 in customer service nationwide!

Hands-On Experience and Professionalism is what makes us the best.

LOOKING FOR OEM PARTS? We can help.
Are you tired of paying overly inflated prices that the dealers charge for their parts? Vivid Racing can save you up to 60% off the dealers' prices. Click here to visit our OEM PARTS STORE.